02-05-2013, 08:52 AM | #46 |
Brigadier General
![]() 154
Rep 3,041
Posts |
|
Appreciate
0
|
02-05-2013, 08:59 AM | #47 | |
Brigadier General
![]() 154
Rep 3,041
Posts |
Quote:
Last edited by ColdList; 02-05-2013 at 07:34 PM.. |
|
Appreciate
0
|
02-05-2013, 10:14 AM | #48 |
BMW obsessed
9587
Rep 10,878
Posts |
Mike,
I am very sorry to hear that you're having trouble with your M5. I have not seen evidence that any Eisenmann systems for the F10 M5 lose power or torque over the OE exhaust, both in our own testing at AMS, in testing at Eisenmann's facility in Germany, and in independent testing by Eisenmann customers worldwide. Our own test results can be seen here: http://f10.m5post.com/forums/showpos...8&postcount=49 ![]() Were you able to test the M5 before and after the exhaust install to check power output? Any noticeable reduction in performance should have shown itself on a dynamometer, and with a dyno graph in hand we could help you in diagnosing your issue. One area I would suggest checking is the vacuum line running to the rear mufflers. If the vacuum lines are not plugged during the exhaust installation your M5's performance can be affected significantly. It is possible that these were left hanging and open during the Eisenmann install, and then re-attached to the OE BMW valves when the OE exhaust system was re-installed. Installers frequently omit installing the vacuum line- so often, in fact, that we have actually moved to attaching warning labels on each exhaust system we ship: "All Eisenmann systems not using the OE vacuum control system must plug and close the vacuum lines at the rear of the car. Failure to do so will result in reduced power and ECU trouble codes." Ultimately it is very difficult to say exactly what happened without hard figures or testing. A simple lap around the block does not give us enough data to diagnose the issue. With regard to tip size and it's effect on power output- Eisenmann tested each tip size in-house for not only power output but decibel output (as required by the German TUV), and found no difference in power output with the larger 102mm tips. A transition from a smaller pipe in the muffler to a larger pipe at the outlet will not reduce power output, as it will not restrict exhaust flow. As a thought experiment, picture which exhaust system would create more exhaust restriction- one with 20mm exhaust tips, or one with no exhaust tips at all? The 20mm exhaust tips would create a major restriction in flow, while the system with no tips (or infinitely large ones) would not have an impact on power output. Exhaust tips are more of a cosmetic finishing item than a contributor to the power output of an exhaust system. Once again, I am very sorry to hear that you've had trouble at all, whether the trouble was related to the installation of the exhaust or not. We are here to support you in any case, whether you'd like to re-install the Eisenmann system and pursue a solution to the problem you felt, or whether you'd like to simply send the exhaust back for a refund.
__________________
|
Appreciate
0
|
02-05-2013, 10:43 AM | #50 | |
Internet Crash Test Dummy
![]() 331
Rep 1,055
Posts
Drives: F97 X3MC / F80 M3 / F90 M5
Join Date: Mar 2006
Location: Under a rock in NH and BOS
|
Quote:
![]() IND's service has been outstanding and you always try to do right by your customers!
__________________
21 F97 X3MC Toronto Red/Black and more | 18 F80 M3 Tanzanite Blue/Amaro/CCB and more
15 F10 M5 Individual / Brilliant White / Extended/Full Cohiba Brown (Exec/Driver/B&O/20") / A few Euro add-ons / Stealth K40 / Upgraded B&O / ///M Performance Carbon Interior Trim / IND / Akrapovic Evolution Exhaust / HRE S107 ![]() |
|
Appreciate
0
|
02-05-2013, 01:20 PM | #52 | |
Lieutenant General
![]() ![]() ![]() 19361
Rep 10,166
Posts |
Quote:
This. I know, it happened to me. I drove away and could not believe that the exhaust did this. Just as its been mentioned that exhaust will not create huge gains; I could not see it causing as much of a power loss as I felt. I drove back and my installer forgot to plug the lines. Boom, instant power return. Ill bet that is what happened here. It was like driving a non boosted turbo car.
__________________
2024 BMW M3 CS Frozen Solid White
2023 BMW M8 Coupe Competition Alpine White 2022 Porsche Carrera GTS Coupe Shark Blue 2020 Audi R8 V10 Performance Suzuka Gray 2012 Mercedes Benz C63 AMG Black Series Obsidian Black |
|
Appreciate
0
|
02-05-2013, 02:58 PM | #53 | |
BMW obsessed
9587
Rep 10,878
Posts |
Quote:
Mike, I am very glad that you and I got to speak today, and I hope to hear from you again soon!
__________________
|
|
Appreciate
0
|
02-05-2013, 03:03 PM | #54 | |
Lieutenant General
![]() ![]() ![]() 19361
Rep 10,166
Posts |
Quote:
Whew I was about to have you credit me back for my Eisenmann since there was so much dialogue here about it robbing power!!!!!!! LOL I kid I kid.... Glad it worked out for the OP.
__________________
2024 BMW M3 CS Frozen Solid White
2023 BMW M8 Coupe Competition Alpine White 2022 Porsche Carrera GTS Coupe Shark Blue 2020 Audi R8 V10 Performance Suzuka Gray 2012 Mercedes Benz C63 AMG Black Series Obsidian Black |
|
Appreciate
0
|
02-05-2013, 03:14 PM | #55 | |
Brigadier General
![]() 154
Rep 3,041
Posts |
Quote:
First of all, Ilia pretty much rocks because he took so much time in personal discussion with me in an effort to resolve my issue. In fact, that has been the case with EVERY interaction with IND. They are by FAR one of the very best vendors that I have ever dealt with, and that is saying quite a bit as I have dealt with countless vendors in modding my BMWs. Secondly, I am hoping that we have isolated the issue, with the help of all of you on here who mentioned vacuum lines. I was initially told that my lines were plugged amply until I really dug today and asked SPECIFICALLY how they were plugged. Let's just say that I am not very convinced that the method was at all appropriate to fully seal off any air seepage. At Ilia's advice, I unplugged the vacuum lines from my stock exhaust and drove the car a bit. I immediately noticed a very similar loss of power to what I was experiencing with the Eisenmann. I then re-attached them and my power was regained. Here is what is happening: Before any validation is made as to the cause I want to be very sure that this is my issue. I am going to have the Eisenmann re-installed and ensure that the lines are plugged properly, with zero room for error. I will then test the car once again. If the issue is fixed then I will be fully satisfied that the vacuum lines were the cause. If this does not fix the issue then I will reinstall the OEM cans and evaluate further. Thank you to everyone who pointed the potential problem out. This is the value that these boards bring. Mike p.s. I owe a humble apology to SANguru for my response. I am definitely good with admitting when I am in error. I'm a bit of a hard head here. As stated, I am not an engineer and as an end user familiar with the quality of feedback on this exhaust prior to making my decision to purchase, I was highly surprised myself to see any drop in performance from an Eisenmann product. My assessment was made solely on my feeling the loss and on the advice of people who I trust to have the expertise. I will post results. I am VERY MUCH hoping that EVERYONE on my end (myself included) is completely wrong. ![]() Last edited by ColdList; 02-06-2013 at 06:53 PM.. |
|
Appreciate
0
|
02-05-2013, 03:18 PM | #56 | |
Brigadier General
![]() 154
Rep 3,041
Posts |
Quote:
![]() Thanks for the input. Mike |
|
Appreciate
0
|
02-05-2013, 03:19 PM | #57 | |
Brigadier General
![]() 154
Rep 3,041
Posts |
Quote:
Man, I cannot WAIT until my HREs get here so I can return this to a solid build thread! Never hurts to add a little drama I guess. Keeps it energized! ![]() |
|
Appreciate
0
|
02-05-2013, 03:25 PM | #58 | |
Lieutenant General
![]() ![]() ![]() 19361
Rep 10,166
Posts |
Quote:
As for the lines, if they are not plugged all your boost leaks out. I remember driving down the road expecting it to downshift (I was in D3) and it just stayed in 3rd gear = boring. Then on the freeway I could barely rock 110 mph and I know there was a boosting issue and the exhaust was somehow related to the boost in regards to the valves. Eisenmann would be out of business real fast if they took our power away with no reason. ![]()
__________________
2024 BMW M3 CS Frozen Solid White
2023 BMW M8 Coupe Competition Alpine White 2022 Porsche Carrera GTS Coupe Shark Blue 2020 Audi R8 V10 Performance Suzuka Gray 2012 Mercedes Benz C63 AMG Black Series Obsidian Black |
|
Appreciate
0
|
02-05-2013, 03:45 PM | #59 |
~~~~~~~~~~~~~
![]() 514
Rep 1,437
Posts |
Was this installed by your BMW guru mechanic who is in the know or someone else?
__________________
2022 Individual M5 Comp
Venetian Violet 2021 X6M Comp 2024 i4 M50 on order IG @purpleM5Comp_NY |
Appreciate
0
|
02-05-2013, 04:14 PM | #61 | |
Internet Crash Test Dummy
![]() 331
Rep 1,055
Posts
Drives: F97 X3MC / F80 M3 / F90 M5
Join Date: Mar 2006
Location: Under a rock in NH and BOS
|
Quote:
Sometimes it is not a bad idea to take in some advice from other folks who also have been around the block ![]() But more important it's great to IND taking care of you and working with you to get you to the point of a working Eisenman.
__________________
21 F97 X3MC Toronto Red/Black and more | 18 F80 M3 Tanzanite Blue/Amaro/CCB and more
15 F10 M5 Individual / Brilliant White / Extended/Full Cohiba Brown (Exec/Driver/B&O/20") / A few Euro add-ons / Stealth K40 / Upgraded B&O / ///M Performance Carbon Interior Trim / IND / Akrapovic Evolution Exhaust / HRE S107 ![]() |
|
Appreciate
0
|
02-05-2013, 05:45 PM | #62 |
Lieutenant
![]() ![]() ![]() 57
Rep 426
Posts |
|
Appreciate
0
|
02-05-2013, 07:02 PM | #63 | |
Brigadier General
![]() 154
Rep 3,041
Posts |
Quote:
Anyway, all good on my end here. Appreciate the feedback. -Mike Last edited by ColdList; 02-05-2013 at 07:25 PM.. |
|
Appreciate
0
|
02-05-2013, 07:07 PM | #64 | |
Brigadier General
![]() 154
Rep 3,041
Posts |
Quote:
![]() No, in fact, against normal practice I actually allowed the dealer to do it as the car was in the air for the 1200 mile service. Figured even a dealer couldn't screw up a simple exhaust install. Again, I was incorrect. Have a bled enough to avoid further shots? :-) |
|
Appreciate
0
|
02-05-2013, 10:22 PM | #66 | |
~~~~~~~~~~~~~
![]() 514
Rep 1,437
Posts |
Quote:
![]() All the best.
__________________
2022 Individual M5 Comp
Venetian Violet 2021 X6M Comp 2024 i4 M50 on order IG @purpleM5Comp_NY |
|
Appreciate
0
|
Post Reply |
Bookmarks |
|
|